This Research Communication describes the initial operation of a pilot-scale intermittently aerated sequencing batch reactor system, which is located at an Irish dairy processing factory. Laboratory-scale research has facilitated the design specifications and operational parameters necessary for the construction and running of a pilot-scale. Laboratory scale research was necessary prior to the pilot scale system to ensure high quality treatment and nutrient removal efficiencies. The pilot system operates with a hydraulic retention time of 4 d, a solids retention time of 16 d and a cycle length of 12 hours. There are 4 non-aeration and aeration phases within the system's react phase. This system has a 3000 l working volume, treating 375 l of wastewater per cycle, 750 l daily. The system was seeded from an aeration tank at the dairy processing factory where the unit is located. The system is operating with the goal to remove both nitrogen and phosphorus from the wastewater biologically, reducing the need for chemical treatment. Currently, the system is performing with high efficiency, treating the wastewater to an acceptable level according to the Irish Environmental Protection Agency for discharge into surrounding water bodies. Therefore, the initial removal results demonstrate this technology's suitability for the treatment of high strength dairy wastewaters.

The objective of the study reported in this Research Communication was to investigate the effects of pectin and whey protein concentrate (WPC) on the generation of acid whey during Greek-style yogurt (GSY) processing. Yogurt samples were prepared using pectin (0·05%, w/v) and whey protein concentrate (WPC-80) (1%, w/v) as possible ingredients that reduce the acid whey production. Control yogurt sample was prepared without addition of these ingredients. The results showed that yogurt made with pectin plus WPC had significantly higher water holding capacity (~56%) than the control (33%). Similarly, yogurt supplemented with pectin plus WPC exhibited 15% less susceptibility to syneresis compared to the control (P < 0·05). Viability of L. bulgaricus and S. thermophilus in all yogurts remained ≥7·0 and ≥8·0 log CFU/g respectively. Native PAGE analysis showed an interaction between pectin and WPC. Pectin hinders the formation of large oligomeric aggregates of whey protein which correlates with an increase in WHC and a decrease in syneresis. Our results demonstrated that a combination of pectin and WPC have the potential to limit the quantity of acid whey generation in GSY manufacturing. Thus, these ingredients have positive implications for dairy industry in the production of GSY.

The spontaneous fermentation of butter produces a highly fragrant product called smen. The short chain fatty acids (C4 to C10) have been traditionally considered the main aromas of this product but our work on the volatile fraction characterisation using SPME GC/MS showed that other products may also be important. Indeed, 183 different volatile compounds were detected belonging mainly to carboxylic acids, esters, ketones, nitrogen compounds and terpenes. However, only 19 compounds were common to more than 50% of the samples. These include short chain fatty acids (C4 to C10), their esters and short chain methylketones (C5 to C11). Despite their high levels in all samples, the amounts of C4 to C10 free fatty acids could not explain the differences in preparation and consumer appreciation of the samples. In contrast, the levels and nature of some methylketones and esters, particularly butanoic and hexanoic ethyl esters and 2-pentanone, seem to better reflect the effects of salt, thyme, acidity and consumer preferences.

This research communication describes the production of flavoured (Mango) curd powder. The mango flavoured curd powder was developed in two different temperatures (150 °C and 170 °C) in various ratios with one control curd sample. The final powder was obtained in high quality which can be used directly or as an ingredient. The percentage of lactic acid in the developed powder showed the healthy amount of probiotic present in it. The physical properties and probiotic growth of the mango flavoured curd powder, developed by spray drying technique, have been evaluated in this article. Various properties were analysed, including moisture content, water activity, dispersibility, bulk and tapped density, porosity, particle morphology, colour analysis, pH, functional group identification using FTIR, identification of the pure culture and % of lactic acid for 3 different Curd and Mango ratios (1:0·5, 1:1, 0·5:1), respectively with one control curd sample. The lactobacillus strain found in this newly developed flavoured powder was Lactobacillus curieae. Lactic acid percentage showed the powder to contain appropriate and healthy amount of probiotic and significant flavour. Future studies are focused on storage studies of the produced powder.

In this Research Communication we investigate potential correlations between key bacterial groups and nutrient removal efficiency in an Intermittently Aerated Sequencing Batch Reactor (IASBR) treating synthetic dairy processing wastewater. Reactor aeration rates of 0·6 and 0·4 litre per minute (LPM) were applied to an 8 l laboratory scale system and the relative impacts on IASBR microbial community structure and orthophosphate (PO4-P) and ammonium (NH4-N) removal efficiencies compared. Aeration at 0·6 LPM over several sludge retention times (SRTs) resulted in approximately 92% removal efficiencies for both PO4-P and NH4-N. Biomass samples subjected to next-generation sequencing (NGS), 16S rRNA profiling revealed a concomitant enrichment of Polaromonas under 0·6 LPM conditions, up to ~50% relative abundance within the reactor biomass. The subsequent shift in reactor aeration to 0·4 LPM, over a period of 3 SRTs, resulted in markedly reduced nutrient removal efficiencies for PO4-P (50%) and NH4-N (45%). An 85·7% reduction in the genus level relative abundance of Polaromonas was observed under 0·4 LPM aeration conditions over the same period.

In this Research Communication we investigate the microbiological profile of 12 dairy wastewater streams from three contrasting Irish dairy processing factories to determine whether faecal indicators/pathogens were present and in turn, whether disinfection may be required for potential water reuse within the factory. Subsequently, the impact of suspended solids on the inactivation efficiency of Escherichia coli via two means of ultravoilet (UV) disinfection; flow-through pulsed UV (PUV) and continuous low pressure UV (LPUV) disinfection was analysed. Faecal indicators total coliforms and E. coli were detected in 10 out of the 12 samples collected at the dairy processing factories while pathogenic bacteria Listeria monocytogenes was detected in all samples collected at 2 out of the 3 factories. Salmonella spp. was undetected in all samples. The results also indicated that organic dairy wastewater solids had an impact on the performance efficiency of the PUV system and, to a lesser extent, the LPUV system. The findings indicate that the targeting of key pathogens would be required to enable wastewater reuse (and indeed effluent discharges if regulation continues to become more stringent) and that LPUV may offer a more robust disinfection method as it appears to be less susceptible to the presence of suspended solids.

The study reported in this Research Communication compared retail milks’ FA profiles from two neighbouring countries, estimated the potential contributions of these milks and a designer milk (achieved by changing the diet of the dairy cow) to the recommended human dietary intake of FA, and predicted (based on the milk FA profile) methane emission from dairy cows. Retail milks in Estonia and Latvia were purchased from supermarkets monthly for one year. To compare the FA composition of retail milk with designer milk with an increased PUFA content, the bulk milk FA profile from a separate field trial was used. Milk FA concentrations of the two neighbouring countries were affected by state, season and their interaction, while the main influence on all these factors were different feeding practices (grazing availability, forage to concentrate ratio and legume-rich silages vs. maize silages). Three cups (600 mL; fat content 2·5 g/100 g) of Estonian, or Latvian retail milk or designer milk per day contributed more to the recommended intakes of saturated FA (SFA) (42·5, 42·7, 38·7%, respectively) than other FA. Compared to the retail milks, α-linolenic acid estimated intake was almost doubled by designer milk consumption (19·7% of adequate intake) without influencing summed intakes of SFA and trans FA. There were state and seasonal differences in the predicted methane outputs of dairy cattle based on retail milk FA. Although the FA profiles of retail milks in the two neighbouring countries were affected by state and season, an appreciable increase in human dietary intakes of beneficial fatty acids from milk, and concomitant reduction in methane emissions from dairy cows, can be achieved only by targeted feeding.

Fermented milk is known to possess potent antioxidant activity. The present study was undertaken to assess the preventive effect of fermented camel milk (FCM) prepared using lactococcus lactis subsp. cremoris against CCl4 induced kidney damage in mice. Nephrotoxicity was induced in mice by a single dose of CCl4 (10 ml/kg 0·3% olive oil, ip). Female mice were pretreated daily with FCM for 15 d. Renal damage was associated with an increase in oxidative stress parameters (lipid peroxidation, protein carbonyl and changes in antioxidant enzyme activities and non-enzymatic antioxidant) and nephropathology markers.

The renal injury induced by CCl4 was confirmed by the histological study of the CCl4-intoxicated mice. Pretreatment with FCM significantly prevented renal dysfunction by reducing oxidative stress, while mice recovered normal kidney histology. Moreover, FCM prevented toxicity biomarker changes by reducing creatinine, urea, uric acid, lactate dehydrogenase (LDH) and electrolytes levels in plasma. These data indicate that FCM is efficient in inhibiting oxidative stress induced by CCl4, and suggests that the administration of this milk may be helpful in the prevention of kidney damage.

This Research Communication describes the methodology used and the subsequent results obtained for an assessment of the environmental impact associated with the manufacture of dairy products in the Republic of Ireland. As the Irish dairy industry changes and grows, it is necessary to have a benchmark of the environmental performance of the sector if it is to remain sustainable in the future. In order to estimate the environmental impact, life cycle assessment has been implemented, which has been structured in accordance with the International Organisation for Standardisation guidelines. In this study, the environmental impact categories assessed are terrestrial acidification potential, cumulative energy demand, freshwater eutrophication potential, global warming potential, marine eutrophication potential and water depletion. The main Irish dairy products have been compared across these environmental impact categories in order to derive meaningful results. It is identified that packaging materials, particularly for infant formula, and energy usage, across each of the life cycle stages, should be targeted as these are the most significant contributors to the overall environmental impact.

We report the fatty acid profile of raw milk and of the corresponding digested milk from different sources (human milk, formula milk and donkey, bovine, ovine and caprine milk) to gain information on the nutritional quality of different milk sources in infant nutrition.

Short chain fatty acids (SC-FA) were higher in bovine and caprine milk, intermediate in ovine and donkey and lower in human and formula milk. Medium chain fatty acids (MC-FA) showed the highest values for bovine and caprine milk and the lowest for donkey and formula milk, whereas long chain fatty acids (LC-FA) were the highest in donkey and formula milk and intermediate in human milk.

The percentage distribution of fatty acids liberated after in vitro digestion did not reflect the patterns found in the corresponding milk sources. In particular, MC free fatty acids (MC-FFA) showed the highest and the lowest values in donkey and in formula milk, LC-FFA showed the highest value in human milk. The total FFA was highest in human milk, lowest in formula milk and intermediate in donkey, bovine, ovine, and caprine milk.