Hostname: page-component-cd9895bd7-dzt6s Total loading time: 0 Render date: 2024-12-19T11:55:41.070Z Has data issue: false hasContentIssue false
  • English
  • Français

LDV measurements of an air–-solid two-phase flow in a horizontal pipe

Published online by Cambridge University Press:  20 April 2006

Yutaka Tsuji  and
Yoshinobu Morikawa
Yutaka Tsuji
Affiliation:
Faculty of Engineering, Osaka University, Osaka, Japan
Yoshinobu Morikawa
Affiliation:
Faculty of Engineering, Osaka University, Osaka, Japan
Get access Rights & Permissions [Opens in a new window]

Abstract

Measurements of air and solid velocities were made in an air-solid two-phase flow in a horizontal pipe by the use of a laser-Doppler velocimeter (LDV). The pipe was 30 mm inner diameter, and two kinds of plastic particles, 0.2 and 3.4 mm in diameter, were conveyed in addition to fine particles (ammonium chloride) for air-flow detection. The air velocities averaged over the pipe cross section ranged from 6 to 20m/s and the solid-to-air mass-flow ratio was up to 6. Simultaneous measurements of both air and 0.2 mm particle velocities were found possible by setting threshold values against the pedestal and Doppler components of the photomultiplier signal.

As the loading ratio increased and the air velocity decreased, mean-velocity distributions of both phases increased asymmetrical tendency. I n the presence of 0.2mm particles, a flattening of the velocity profile was remarkable. The effects of the solid particles on air-flow turbulence varied greatly with particle size. That is, 3.4 mm particles increased the turbulence markedly, while 0-2 mm ones reduced it. The probability-density function of the air flow deviated from the normal distribution (Gaussian) in the presence of particles. Finally, the frequency spectra of air-flow turbulence were obtained in the presence of 0.2 mm particles by using a fast Fourier transform (FFT). As a result, it was found that t,he higher-frequency components increased with increasing loading ratio.

Type
Research Article
Information
Journal of Fluid Mechanics , Volume 120 , July 1982 , pp. 385 - 409
Copyright
© 1982 Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Achenbach, E. 1974 Vortex shedding from spheres. J. Fluid Mech. 62, 206.Google Scholar
Adam, O. 1957 Feststoffbeladene Luftströmung hoher Geschwindigkeit. Chem. Ing. Tech. 29, 151.Google Scholar
Birchenough, A. & Mason, J. S. 1976 Local particle velocity measurements with a laser anemometer in an upward flowing gas—solid suspension. Powder Tech. 14, 139.Google Scholar
Buchhave, P., George, W. K. & Lumley, J. L. 1979 The measurement of turbulence with the laser-Doppler anemometer. Ann. Rev. Fluid Mech. 11, 443.Google Scholar
Doig, I. D. & Roper, G. H. 1967 Air velocity profiles in presence of concurrently transported particles. Ind. & Engng Chem. Fund. 6, 247.Google Scholar
Durst, F., Melling, A. & Whitelaw, J. H. 1976 Principles and Practice of Laser-Doppler Anemometry, p. 303. Academic.
Durst, F. & Umhauer, H. 1975 Local measurements of particle velocity, size distribution and concentration with a combined laser Doppler particle sizing system. In Proc. LDA Symp., Copenhagen, p. 430.
Gasterstädt, J. 1924 Die experimentelle Untersuchung des pneumatischen Fördervorganges. Forsch. Arb. Ing. Wes. no. 265.
George, W. K. 1975 Limitations to measuring accuracy inherent in the laser Doppler signal. In Proc. LDA Symp., Copenhagen, p. 20.
Jotaki, T. & Tomita, Y. 1971 Solids velocities and pressure drops in a horizontal pneumatic conveying systems. In Proc. 1st Conf. Pneumatic Transport of Solids in Pipes, BHRA Fluid Engng, paper B3.
Kramer, T. J. & Depew, C. A. 1972 Experimentally determined mean flow characteristics of gas—solid suspensions. Trans. A.S.M.E. D, J. Fluids Engng 94, 492.Google Scholar
Maeda, M., Mitsueda, T. & Ikai, S. 1976 The investigation of heat transfer in a gas—solid two phase flow (the 1st report, experiment and discussion of the heat transfer by the free stream turbulence) (in Japanese). Trans. Japan Soc. Mech. Engrs, series 2, 42, 866.Google Scholar
Maeda, M., Hishida, K. & Furutani, T. 1980 Velocity distributions of air—solid suspension in upward pipe flow (effect of particles on air velocity distribution) (in Japanese). Trans. Japan Soc. Mech. Engrs B 46, 2313.Google Scholar
Ohba, K. & Yuhara, T. 1979 Velocity measurements of both phases in two-phase flow using laser doppler velocimeter. In Proc. IMEKO Symp., Tokyo, p. 181.
Owen, P. R. 1969 Pneumatic transport. J. Fluid Mech. 39, 407.Google Scholar
Soo, S. L., Ihrig, H. K. & El Kouh, A. F. 1960 Experimental determination of statistical properties of two-phase turbulent motion. Trans. A.S.M.E. D, J. Fluids Engng 82, 609.Google Scholar
Torovin, L. B. & Gauvin, W. H. 1960 Fundamental aspects of solids—gas flow. Part 5. The effects of fluid turbulence on the particle drag coefficient. Can. J. Chem. Engng 38, 189.Google Scholar
Welschof, G. 1962 Pneumatische Förderung bei grossen Fordergutkonzentrationen. VDI Forsch. no. 492.Google Scholar
Zisselmar, R. & Molerus, O. 1979 Experimentelle Untersuchungen zum Turbulenzverhalten der Suspensionsströmung in horizontalen Rohrleitungen. Chem. Ing. Tech. 51, 50.Google Scholar