Hostname: page-component-78c5997874-94fs2 Total loading time: 0 Render date: 2024-11-12T21:14:27.821Z Has data issue: false hasContentIssue false
  • English
  • Français

Milk protein standardization by ultrafiltration for Cheddar cheese manufacture

Published online by Cambridge University Press:  01 June 2009

Timothy P. Guinee ,
Donal J. O'Callaghan ,
Edward O. Mulholland  and
Dermot Harrington
Timothy P. Guinee
Affiliation:
National Dairy Products Research Centre, Teagasc, Moorepark, Fermoy, Co. Cork, Irish Republic
Donal J. O'Callaghan
Affiliation:
National Dairy Products Research Centre, Teagasc, Moorepark, Fermoy, Co. Cork, Irish Republic
Edward O. Mulholland
Affiliation:
National Dairy Products Research Centre, Teagasc, Moorepark, Fermoy, Co. Cork, Irish Republic
Dermot Harrington
Affiliation:
Statistics Department, Teagasc, 19 Sandymount Avenue, Dublin 4, Irish Republic
Get access Rights & Permissions [Opens in a new window]

Summary

Skim milks were concentrated by ultrafiltration. Cream was added to the retentates to give cheesemilks standardized to a casein: fat ratio of ∼ 0·74 with protein levels ranging from 30 to 46 g/1. Pasteurized cheesemilks were renneted on a volume basis (22 ml single strength calf rennet/100 1) and converted to Cheddar cheese in 500 1 cheese vats. Set temperatures were reduced from 31 to 28 °C with increasing milk protein level to normalize curd firming rates and prevent curd shattering on cutting the curds. Cheesemaking was otherwise as normal for Cheddar cheese. The proportions of milk fat and protein lost in the cheese whey were not significantly influenced by milk protein level. Moisture-adjusted cheese yields increased with milk protein at a rate similar to that predicted by the Van Slyke cheese yield equation. However, owing to the negative correlation between cheese moisture and milk protein concentration, actual yields increased at a lower rate with respect to milk protein than moisture-adjusted yields. Increasing milk protein levels resulted in significant (P < 0·01–0·001) decreases in the concentrations of moisture, moisture-in-non-fat cheese solids and fat-in-dry matter in the cheese and increases (P < 0·05–0·001) in the levels of protein, salt-in-moisture, Ca and P. While increasing milk protein concentration resulted in significant (P < 0·05–0·01) reductions in the levels of water-soluble N at all stages of the 270d ripening period, it had little influence on the sensory scores awarded for aroma/flavour at 180 or 270d.

Type
Original Articles
Information
Journal of Dairy Research , Volume 63 , Issue 2 , May 1996 , pp. 281 - 293
Copyright
Copyright © Proprietors of Journal of Dairy Research 1996

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Banks, J. M., Banks, W., Muir, D. D. & Wilson, A. G. 1981 Cheese yield. Composition does matter. Dairy Industries International 46 (5) 15, 17, 19, 21–22Google Scholar
Barbano, D. M. & Bynum, D. G. 1984 Whole milk reverse osmosis retentates for Cheddar cheese manufacture: cheese composition and yield. Journal of Dairy Science 67 2839–2849CrossRefGoogle Scholar
Barry, J. G. & Donnelly, W. J. 1981 Casein compositional studies. II. The effect of secretory disturbance on casein composition in freshly drawn and aged bovine milks. Journal of Dairy Research 48 437–446CrossRefGoogle Scholar
Bush, C. S., Caroutte, C. A., Amundson, C. H. & Olson, N. F. 1983 Manufacture of Colby and brick cheeses from ultrafiltered milk. Journal of Dairy Science 66 415–421CrossRefGoogle Scholar
Bynum, D. G. & Barbano, D. M. 1985 Whole milk reverse osmosis retentates for Cheddar cheese manufacture: chemical changes during aging. Journal of Dairy Science 68 1–10CrossRefGoogle Scholar
Bynum, D. G. & Olson, N. F. 1982 Influence of curd firmness at cutting on Cheddar cheese yield and recovery of milk constituents. Journal of Dairy Science 65 2281–2290CrossRefGoogle Scholar
Casiraghi, E. M., Peri, C. & Piazza, L. 1987 Effect of calcium equilibria on the rate of syneresis and on the firmness of curds obtained from UF retentates. Mikhwissenschaft 42 232–235Google Scholar
Chapman, H. R., Bines, V. E., Glover, F. A. & Skudder, P. J. 1974 Use of milk concentrated by ultrafiltration for making hard cheese, soft cheese and yoghurt. Journal of the Society of Dairy Technology 27 151–155CrossRefGoogle Scholar
Chapman, H. R. & Burnett, J. 1972 Seasonal changes in the physical properties of milk for cheesemaking. Dairy Industries 37 207–211Google Scholar
Creamer, L. K., Iyer, M. & Lelievre, J. 1987 Effect of various levels of rennet addition on characteristics of Cheddar cheese made from ultrafiltered milk. New Zealand Journal of Dairy Science and Technology 22 205–214Google Scholar
Creamer, L. K. & Olson, N. F. 1982 Rheological evaluation of maturing Cheddar cheese. Journal of Food Science 47 631–636, 646CrossRefGoogle Scholar
Green, M. L., Glover, F. A., Scurlock, E. M. W., Marshall, R. J. & Hatfield, D. S. 1981 a Effect of use of milk concentrated by ultrafiltration on the manufacture and ripening of Cheddar cheese. Journal of Dairy Research 48 333–341CrossRefGoogle Scholar
Green, M. L., Scott, K. J., Anderson, M., Griffin, M. C. A. & Glover, F. A. 1984 Chemical characterization of milk concentrated by ultrafiltration. Journal of Dairy Research 51 267–278CrossRefGoogle Scholar
Green, M. L., Turvey, A. & Hobbs, D. G. 1981 b Development of structure and texture in Cheddar cheese. Journal of Dairy Research 48 343–355CrossRefGoogle Scholar
Guinee, T. P., O'Callaohan, D. J. & Pudja, P. D. 1996 Rennet coagulation properties of retentates obtained by ultrafiltration of skim milks heated to different temperatures. International Dairy Journal (In press)CrossRefGoogle Scholar
Guinee, T. P., Pudja, P. D. & Mulholland, E. O. 1994 Effect of milk protein standardization, by ultrafiltration, on the manufacture, composition and maturation of Cheddar cheese. Journal of Dairy Research 61 117–131CrossRefGoogle Scholar
Hickey, M. W. & Versteeg, C. 1993 Mozzarella cheese with ultrafiltration retentate. Australian Journal of Dairy Technology 48 44–47Google Scholar
Institute for Industrial Research and Standard. 1955 a Determination of the percentage fat in milk. (Irish Standard no. 66)Google Scholar
Institute for Industrial Research and Standard. 1955 b Determination of the percentage fat in cheese. (Irish Standard no. 69)Google Scholar
International Dairy Federation. 1964 Determination of the casein content of milk. Brussels: IDF (FIL–IDF Standard no. 29)Google Scholar
International Dairy Federation. 1982 Cheese and processed cheese. Determination of the total solids content (reference method). Brussels: IDF (FIL–IDF Standard no. 4A)Google Scholar
International Dairy Federation. 1986 Milk. Determination of the nitrogen content (Kjeldahl method) and calculation of crude protein content. Brussels: IDF (FIL–IDF Standard no. 20A)Google Scholar
International Dairy Federation. 1987 a Calf and adult bovine rennet. Determination of chymosin and bovine pepsin contents (chromatographic method). Brussels: IDF (FIL–IDF Standard no. 110A)Google Scholar
International Dairy Federation. 1987 b Skimmed milk, whey and buttermilk. Determination of fat content – Röse Gottlieb gravimetric method (reference method). Brussels: IDF (FIL–IDF Standard no. 22B)Google Scholar
International Dairy Federation. 1988 Cheese and processed cheese products. Determination of chloride content. Potentiometric method. Brussels: IDF (FIL–IDF Standard no. 88A)Google Scholar
Jameson, G. W. 1987 Manufacture of Cheddar cheese from milk concentrated by ultrafiltration: the development and evaluation of a process. Food Technology in Australia 39 560–564Google Scholar
Johnston, K. A., Dunlop, F. P., Coker, C. J. & Wards, S. M. 1994 Comparisons between the electrophoretic pattern and textural assessment of aged Cheddar cheese made using various levels of calf rennet or microbial coagulant (Rennilase 46L). International Dairy Journal 4 303–327CrossRefGoogle Scholar
Johnston, K. A., Dunlop, F. P. & Lawson, M. F. 1991 Effects of speed and duration of cutting in mechanized Cheddar cheesemaking on curd particle size and yield. Journal of Dairy Research 58 345–354CrossRefGoogle Scholar
Keogh, M. K., Kelly, P. M., O'Keeffe, A. M. & Phelan, J. A. 1982 Studies of milk composition and its relationship to some processing criteria. 2. Seasonal variation in the mineral levels of milk. Irish Journal of Food Science and Technology 6 13–27Google Scholar
Kindstedt, P. S. & Kosikowski, F. V. 1985 Alternative test for phosphorus in cheese. Journal of Dairy, Science 68 1859–1864CrossRefGoogle Scholar
Kuchroo, C. N. & Fox, P. F. 1982 Soluble nitrogen in Cheddar cheese: comparison of extraction procedures. Milchwissenschaft 37 331–335Google Scholar
Lawrence, R. C. 1989 The use of ultrafiltration technology in cheesemaking. International Dairy Federation Bulletin no. 240 2–15Google Scholar
Lawrence, R. C. & Gilles, J. 1993. Cheddar cheese and related dry-salted varieties. In Cheese: Chemistry, Physics and Microbiology. 2. Major cheese groups, 2nd edn, pp. 1–38 (Ed. Fox, P. F.). London: Chapman & HallGoogle Scholar
Lucey, J. & Kelly, J. 1994 Cheese yield. Journal of the Society of Dairy Technology 47 1–14CrossRefGoogle Scholar
Lucey, J. A., Kindstedt, P. S. & Fox, P. F. 1992 Seasonality: its impact on the production of good quality Mozzarella cheese. In 3rd Cheese Symposium, Moorepark, pp. 41–47 (Ed. Cogan, T. M.). Moorepark: National Dairy Products Research CentreGoogle Scholar
Office of the Federal Register 1986 National Archives and Records Administration 21 Food and Drugs, Parts 100–169. Part 133 Cheese and cheese related subjects, pp. 185–186. Washington, DC: US Government Printing OfficeGoogle Scholar
O'Keeffe, A. M. 1984 Seasonal and lactational influences on moisture content of Cheddar cheese. Irish Journal of Food Science and Technology 8 27–37Google Scholar
Peleg, M. 1976 Texture profile analysis parameters obtained by an Instron Universal Testing Machine. Journal of Food Science 41 721–722CrossRefGoogle Scholar
Phelan, J. A., O'Keeffe, A. M., Keogh, M. K. & Kelly, P. M. 1982 Studies of milk composition and its relationship to some processing criteria. 1. Seasonal changes in the composition of Irish milk. Irish Journal of Food Science and Technology 6 1–11Google Scholar
Prentice, J. H., Langley, K. R. & Marshall, R. J. 1993 Cheese rheology. In Cheese: Chemistry, Physics and Microbiology. 1. General aspects, 2nd edn, pp. 303–340 (Ed. Fox, P. F.). London: Chapman & HallCrossRefGoogle Scholar
Srilaokkul, S., Ozimek, L., Ooraikul, B., Hadziyev, D. & Wolfe, F. 1991 Effect of ultrafiltration of skim milk on casein micelle size distribution in retentate. Journal of Dairy Science 74 50–57CrossRefGoogle Scholar
Stadhouders, J. 1960 [The hydrolysis of protein during the ripening of Dutch cheese. Enzymes and bacteria involved.] Netherlands Milk and Dairy Journal 14 83–110Google Scholar
Thomas, T. D. & Pearce, K. N. 1981 Influence of salt on lactose fermentation and proteolysis in Cheddar cheese. New Zealand Journal of Dairy Science and Technology 16 253–259Google Scholar
Van Den Berg, G., De Vries, E. & Arentzen, A. G. J. 1973 [Which sampling method is most suitable for accurate determination of the curd fines content of the first whey ?] Officieel Orgaan, Koninklijke Nederlandse Zuiuelbond 65 825–828Google Scholar
Van Dijk, H. J. M. & Walstra, P. 1986 Syneresis of curd. 2. One-dimensional syneresis of rennet curd in constant conditions. Netherlands Milk and Dairy Journal 40 3–30Google Scholar
White, J. C. D. & Davies, D. T. 1958 The relation between the chemical composition of milk and the stability of the caseinate complex. 1. General introduction, description of samples, methods and chemical composition of samples. Journal of Dairy Research 25 236–255CrossRefGoogle Scholar
Whitehead, H. R. & Harkness, W. L. 1954 The influence of variations in cheesemaking procedure on the expulsion of moisture from Cheddar cheese curd. Australian Journal of Dairy Technology 9 103–107Google Scholar