Hostname: page-component-586b7cd67f-vdxz6 Total loading time: 0 Render date: 2024-11-28T17:48:03.765Z Has data issue: false hasContentIssue false
  • English
  • Français

Structural Analysis of Nanocrystalline Silicon Prepared by Hot-wire Chemical Vapor Deposition on Polymer Substrates

Published online by Cambridge University Press:  01 February 2011

Michael Musashi Adachi ,
Farhad Taghibakhsh ,
Karen L. Kavanagh  and
Karim S. Karim
Michael Musashi Adachi
Affiliation:
[email protected], Simon Fraser University, School of Engineering Science, 8888 University Drive, Burnaby, V5A 1S6, Canada, 1-604-825-2164
Farhad Taghibakhsh
Affiliation:
[email protected], Simon Fraser University, School of Engineering Science, 8888 University Drive, Burnaby, V5A 1S6, Canada
Karen L. Kavanagh
Affiliation:
[email protected], Simon Fraser University, Department of Physics, 8888 University Drive, Burnaby, V5A 1S6, Canada
Karim S. Karim
Affiliation:
[email protected], Simon Fraser University, School of Engineering Science, 8888 University Drive, Burnaby, V5A 1S6, Canada
Get access

Abstract

Nanocrystalline silicon (nc-Si:H) films were deposited by hot-wire chemical vapor deposition (HWCVD) directly onto Corning glass and polyimide (Kapton E) substrates. The effect of silane concentration (in hydrogen carrier gas) on film crystallinity and conductivity were studied for a constant substrate growth temperature of 220°C. Raman spectroscopy, X-ray diffraction and cross-sectional transmission electron microscopy (XTEM) showed that nc-Si:H (grain-size 20-65 nm) was observed for silane concentrations below 5.8 %. Similar to previous reports, closer inspection using XTEM found that there was an initial growth of an amorphous interfacial layer which then crystallized into a randomly-oriented polycrystalline material after 10 - 100 nm of growth.. However, unlike previous reports, there was no detectable difference in the structure or conductivity for films grown on the two types of substrates. In both cases, the dark conductivity decreased with increasing silane concentration while the photo-conductivity was uniform for all films at values between 2 and 4×10-5 S/cm.

Keywords

Sichemical vapor deposition (CVD) (deposition)crystalline
Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 989: Symposium A – Amorphous and Polycrystalline Thin-Film Silicon Science and Technology-2007 , 2007 , 0989-A22-03
Copyright
Copyright © Materials Research Society 2007

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1 Wiesmann, H., Ghosh, A. K., McMahon, T., Strongin, M., J. Appl. Phys. 50 (1979) 3752–3754.Google Scholar
2 Matsumura, H., Japanese J. Appl. Phys. 37 (1998) 3175–87.Google Scholar
3 Ledermann, A., Weber, U., Mukherjee, C., Schroeder, B., Thin Solid Films 395 (2001) 61–65.Google Scholar
4 Erickson, K., Dalal, V. L., J. Non-crystalline Solids, 266-269 (2000) 685–688.Google Scholar
5 Adachi, M. M., Tse, W. F. L., Cluff, G., Kavanagh, K. L., Karim, K. S., Mater. Res. Soc. Symp. Proc. 910 (2006) 0910-A08-05.Google Scholar
6 Veen, Van, Katherine, Marieke, Ph.D. Thesis, Utrecht University, Netherlands, 23-46 2003.Google Scholar
7 Klein, S., Repmann, T., Brammar, T., Solar Energy 77, (2004) 893–908.Google Scholar
8 Klein, S., Finger, F., Carius, R., Wagner, H., Strutzmann, M., Thin Solid Films 395 (2001) 305–309.Google Scholar
9 Moutinho, H.R., Jiang, C.S., Perkins, J., Xu, Y., Nelson, B.P., Jones, K.M., Romero, M.J., Al-Jassim, M.M., Thin Solid Films 430 (2003) 135–140.Google Scholar
10 Bailat, J., Vallet-Sauvain, E., Feitknecht, L., Droz, C., Shah, A., J. Appl. Phys. 93 (2003) 5727–5732.Google Scholar
11 Williams, D.B., Carter, C.B., Transmission Electron Microscopy, (Plenum Press, New York, 1996), pp. 265–286.Google Scholar