Hostname: page-component-586b7cd67f-r5fsc Total loading time: 0 Render date: 2024-11-28T16:25:19.842Z Has data issue: false hasContentIssue false
  • English
  • Français

Preparation of Nanocrystalline Silicon by Pulsed Plasma Processing

Published online by Cambridge University Press:  28 February 2011

S. Oda  and
M. Otobe
S. Oda
Affiliation:
Department of Physical Electronics, Tokyo Institute of Technology O-okayama, Meguro-ku, Tokyo 152, Japan
M. Otobe
Affiliation:
Department of Physical Electronics, Tokyo Institute of Technology O-okayama, Meguro-ku, Tokyo 152, Japan
Get access

Abstract

We have proposed digital plasma processing for the fabrication of silicon quantum dots with grain size less than l0nm. By using the pulsed gas supply of SiH4 and H2 in the very-high frequency (VHF) plasma, we have clarified the role of atomic hydrogen in the nucleation, crystallization of nanocrystalline Si (nc-Si) as well as in the selective etching of amorphous Si to nc-Si. Recently, we have prepared nc-Si by employing an ultra-high-vacuum (UHV) chamber equipped with VHF plasma cells of SiH4 and H2. Flux rate of Si cluster depends significantly on the pressure of the plasma cell and VHF power. Spherical shaped nc-Si clusters less than 6nm in diameter have been observed by transmission electron microscopy (TEM). Infrared absorption measurements have clarified that the surface of nc-Si is covered by hydrogen. In an attempt to control the position of nuclei, we have prepared nc-Si on SiO2 with micro trenches, 40nm wide and 20nm deep, fabricated by electron beam exposure and electron cyclotron resonance (ECR) etching. It has been revealed by TEM observation that nc-Si are formed preferentially along micro trenches.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 358: Symposium F – Microcrystalline and Nanocrystalline Semiconductors , 1994 , 721
Copyright
Copyright © Materials Research Society 1995

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1 Sugimoto, T., Adv. Colloid Interface Sci. 28, 65 (1987).Google Scholar
2 Nielsen, A. E., Kinetics of Precipitation, (Pergamon, Oxford, 1964).Google Scholar
3 Otobe, M. and Oda, S., Jpn. J. Appl. Phys. 31, 1948 (1992).Google Scholar
4 Oda, S., Plasma Source Sci. & Technol. 2, 26 (1993).Google Scholar
5 Otobe, M. and Oda, S., Jpn. J. Appl. Phys. 31, L1443 (1992).Google Scholar
6 Otobe, M. and Oda, S., J. Non-Cryst. Solids, 164/166, 993 (1993).Google Scholar
7 Otobe, M. and Oda, S., in Microcrystalline Semiconductors: Materials Science and Devices, edited by Fauchet, P.M. et al. (Mater. Res. Soc. Proc. 283, Pittsburgh, PA, 1992) pp.519–524.Google Scholar
8 Otobe, M. and Oda, S., Jpn. J. Appl. Phys. 31, L1388 (1992).Google Scholar
9 Otobe, M., Kimura, M. and Oda, S., Jpn. J. Appl. Phys. 33, 4442 (1994).Google Scholar
10 Miyazaki, S., Inoue, Y., Kiriki, Y. and Hirose, M., Jpn. J. Appl. Phys. 28, 2382 (1989).Google Scholar
11 Takagi, H., Ogawa, H., Yamazaki, Y., Ishizaki, A. and Nakagiri, T., Appl. Phys. Lett. 56, 2379 (1990).Google Scholar
12 Jellum, G. M., Daugherty, J. E. and Graves, D. B., J. Appl. Phys. 69, 6923 (1991).Google Scholar
13 Jansson, U. and Uram, K. J., J. Chem. Phys. 91, 7978 (1989).Google Scholar
14 Moniwa, M., Kusukawa, K., Ohkura, M. and Takeda, E., Jpn. J. Appl. Phys. 32, 312 (1993).Google Scholar