Hostname: page-component-586b7cd67f-dlnhk Total loading time: 0 Render date: 2024-11-28T18:41:13.941Z Has data issue: false hasContentIssue false
  • English
  • Français

The influence of secondary flows induced by normal stress differences on the shear-induced migration of particles in concentrated suspensions

Published online by Cambridge University Press:  30 April 2008

ARUN RAMACHANDRAN  and
DAVID T. LEIGHTON JR
ARUN RAMACHANDRAN
Affiliation:
Department of Chemical Engineering, University of California at Santa Barbara, CA 93106, USA
DAVID T. LEIGHTON JR
Affiliation:
Department of Chemical and Biomolecular Engineering, University of Notre Dame, Notre Dame, IN 46556, USA
Get access Rights & Permissions [Opens in a new window]

Abstract

It was first demonstrated experimentally by H. Giesekus in 1965 that the second normal stress difference in polymers can induce a secondary flow within the cross-section of a non-axisymmetric conduit. In this paper, we show through simulations that the same may be true for suspensions of rigid non-colloidal particles that are known to exhibit a strong negative second normal stress difference. Typically, the magnitudes of the transverse velocity components are small compared to the average axial velocity of the suspension; but the ratio of this transverse convective velocity to the shear-induced migration velocity is characterized by the shear-induced migration Péclet number χ which scales as B2/a2, B being the characteristic length scale of the cross-section and a being the particle radius. Since this Péclet number is kept high in suspension experiments (typically 100 to 2500), the influence of the weak circulation currents on the concentration profile can be very strong, a result that has not been appreciated in previous work. The principal effect of secondary flows on the concentration distribution as determined from simulations using the suspension balance model of Nott & Brady (J. Fluid Mech. vol. 275, 1994, p. 157) and the constitutive equations of Zarraga et al. (J. Rheol. vol. 44, 2000, p. 185) is three-fold. First, the steady-state particle concentration distribution is no longer independent of particle size; rather, it depends on the aspect ratio B/a. Secondly, the direction of the secondary flow is such that particles are swept out of regions of high streamsurface curvature, e.g. particle concentrations in corners reach a minimum rather than the local maximum predicted in the absence of such flows. Finally, the second normal stress differences lead to instabilities even in such simple geometries as plane-Poiseuille flow.

Type
Papers
Information
Journal of Fluid Mechanics , Volume 603 , 25 May 2008 , pp. 207 - 243
Copyright
Copyright © Cambridge University Press 2008

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Abbott, J. R., Tetlow, N., Graham, A. L., Altobelli, S. A., Fukushima, E., Mondy, L. A. & Stephens, T. S. 1991 Experimental observations of particle migration in concentration suspensions: Couette flow. J. Rheol. 35, 773–795.CrossRefGoogle Scholar
Acrivos, A., Mauri, R. & Fan, X. 1993 Shear-induced resuspension in a Couette device. Intl J. Multiphase Flow 19, 797–802.CrossRefGoogle Scholar
Altobelli, S. A., Givler, R. C. & Fukushima, E. 1991 Velocity and concentration measurements of suspensions by nuclear magnetic resonance imaging. J. Rheol. 35, 721–734.CrossRefGoogle Scholar
Brady, J. F. & Carpen, I. E. 2002 Second normal stress jump instability in non-Newtonian fluids. J. Non-Newtonian Fluid Mech. 102, 219–232.CrossRefGoogle Scholar
Bricker, J. M. & Butler, J. E. 2006 Oscillatory shear of suspensions of non-colloidal particles. J. Rheol. 50, 711–728.CrossRefGoogle Scholar
Chapman, B. K. 1990 Shear-induced migration phenomena in suspensions. PhD thesis, University of Notre Dame.Google Scholar
Chapman, B. K. & Leighton, D. T. 1991 Dynamic viscous resuspension. Intl J. Multiphase Flow 17, 469–483.CrossRefGoogle Scholar
Chow, A. W., Sinton, S. W., Iwamiya, J. H. & Stephens, T. S. 1994 Shear-induced particle migration in Couette and parallel-plate viscometers: NMR imaging and stress measurement. Phys. Fluids 6 (8), 2561–2576.CrossRefGoogle Scholar
Chow, A. W., Sinton, A. W., Iwamiya, J. H. & Leighton, D. T. 1995 Particle migration of non-Brownian concentrated suspensions in a truncated cone and plate. Poster at Society of Rheology meeting.Google Scholar
DaCunha, F. R. & Hinch, E. J. 1996 Shear-induced dispersion in a dilute suspension of rough spheres. J. Fluid Mech. 309, 211–223.CrossRefGoogle Scholar
Debbaut, B. & Dooley, J. 1999 Secondary motions in straight and tapered channels: experiments and three-dimensional finite element simulation with a multimode differential viscoelastic model. J. Rheol. 43, 1525–1545.CrossRefGoogle Scholar
Debbaut, B., Avalosse, T., Dooley, J. & Hughes, K. 1997 On the development of secondary motions in straight channels induced by the second normal stress difference: experiments and simulations. J. Non-Newtonian Fluid Mech. 69, 255–271.CrossRefGoogle Scholar
Dodson, A. G., Townsend, P. & Walters, K. 1974 Non-Newtonian flow in pipes of non-circular cross-section. Computers Fluids 19, 317–338.CrossRefGoogle Scholar
Fang, Z., Mammoli, A. A., Brady, J. F., Ingber, M. S., Mondy, L. A. & Graham, A. L. 2002 Flow-aligned tensor models for suspension flows. Intl J. Multiphase Flow 28, 137–166.CrossRefGoogle Scholar
Giesekus, H. 1965 Sekundarstromungen in viskoelastischen Flussigkeiten bei stationarer und periodischer Bewegung. Rheol. Acta 4, 85–101.CrossRefGoogle Scholar
Green, A. E. & Rivlin, R. S. 1956 Steady flow of non-Newtonian fluids through tubes. Q. Appl. Maths 14, 229–308.Google Scholar
Hampton, R. E., Mammoli, A. A., Graham, A. L. & Tetlow, N. 1997 Migration of particles undergoing pressure-driven flow in a circular conduit. J. Rheol. 41, 621–640.CrossRefGoogle Scholar
Jana, S. C., Kapoor, B. & Acrivos, A. 1995 Apparent wall slip velocity coefficients in concentrated suspensions of noncolloidal particles. J. Rheol. 39, 1123–1132.CrossRefGoogle Scholar
Jenkins, J. T. & McTigue, D. F. 1990 Two Phase Flows and Waves, pp. 70–79. Springer.CrossRefGoogle Scholar
Koh, C. J., Hookham, P. & Leal, L. G. 1994 An experimental investigation of concentrated suspension flows in a rectangular channel. J. Fluid Mech. 266, 1–32.CrossRefGoogle Scholar
Krishnan, G. P., Beimfohr, S. & Leighton, D. T. 1996 Shear-induced radial segregation in bidisperse suspensions. J. Fluid Mech. 321, 371–393.CrossRefGoogle Scholar
Leighton, D. & Acrivos, A. 1986 Viscous resuspension. Chem. Engng Sci. 41, 1377–1384.CrossRefGoogle Scholar
Leighton, D. & Acrivos, A. 1987 The shear-induced migration of particles in concentrated suspensions. J. Fluid Mech. 181, 415–439.CrossRefGoogle Scholar
Lyon, M. K. & Leal, L. G. 1998 An experimental study of the motion of concentrated suspensions in two-dimensional channel flow. Part 1. Monodisperse systems. J. Fluid Mech. 363, 25–56.CrossRefGoogle Scholar
Merhi, D., Lemaire, E., Bossis, G. & Moukalled, F. 2005 Particle migration in a concentrated suspension flowing between rotating parallel plates: investigation of diffusion flux coefficients. J. Rheol. 49, 1429–1448.CrossRefGoogle Scholar
Miller, R. M. & Morris, J. F. 2006 Normal stress-driven migration and axial development in pressure-driven flow of concentrated suspensions. J. Non-Newtonian Fluid Mech. 135 (2-3), 149–165.CrossRefGoogle Scholar
Mills, P. & Snabre, P. 1995 Rheology and structure of concentrated suspension of hard spheres: shear-induced particle migration. J. de Phys. II 5, 1597–1608.Google Scholar
Morris, J. F. & Boulay, F. 1999 Curvilinear flows of non-colloidal suspensions: the role of normal stresses. J. Rheol. 43, 1213–1237.CrossRefGoogle Scholar
Norman, J. T., Nayak, H. V. & Bonnecaze, R. T. 2005 Migration of buoyant particles in low Reynolds number pressure-driven flows. J. Fluid Mech. 523, 1–35.CrossRefGoogle Scholar
Nott, P. R. & Brady, J. F. 1994 Pressure-driven flow of suspensions: simulations and theory. J. Fluid Mech. 275, 157–199.CrossRefGoogle Scholar
Phan-Thien, N. 1995 Constitutive equation for concentrated suspensions in Newtonian liquids. J. Rheol. 39, 679–695.CrossRefGoogle Scholar
Phillips, R. J., Armstrong, R. C., Brown, R. A., Graham, A. L. & Abbott, J. R. 1992 A constitutive model for concentrated suspensions that accounts for shear-induced particle migration. Phys. Fluids A 4, 30–40.CrossRefGoogle Scholar
Ramachandran, A. & Leighton, D. T. 2007 Viscous resuspension in a tube: the impact of secondary flows resulting from second normal stress differences. Phys. Fluids 19 (5), 055301.CrossRefGoogle Scholar
Schaflinger, U., Acrivos, A. & Zhang, K. 1990 Viscous resuspension of a sediment within a laminar and stratified flow. Intl J. Multiphase Flow 16, 567–578.CrossRefGoogle Scholar
Semjonow, V. 1967 Sekundarstromungen hochpolymerer Schmelzen in einem Rohr von elliptischem Querschnitt. Rheol. Acta 6, 171–173.CrossRefGoogle Scholar
Shapley, N., Armstrong, R. C. & Brown, R. A. 2002 Laser doppler velocimetry measurements of particle velocity fluctuations in a concentrated suspension. J. Rheol. 46, 241–272.CrossRefGoogle Scholar
Shauly, A., Averbakh, A., Nir, A. & Semiat, R. 1997 Slow viscous flows of highly concentrated suspensions: Part II – particle migration, velocity and concentration profiles in rectangular ducts. Intl J. Multiphase Flow 23, 613–629.CrossRefGoogle Scholar
Smart, J. & Leighton, D. T. 1989 Measurement of the hydrodynamic surface roughness of noncolloidal spheres. Phys. Fluids A 1 (1), 52–60.CrossRefGoogle Scholar
Tetlow, N., Graham, A. L., Ingber, M. S., Subia, S. R., Mondy, L. A. & Altobelli, S. A. 1998 Particle migration in a Couette apparatus: experiment and modeling. J. Rheol. 42, 307–327.CrossRefGoogle Scholar
Tirumkudulu, M. S. 2001 Viscous resuspension and particle segregation in concentrated suspensions undergoing shear. PhD thesis, City University of New York.Google Scholar
Tripathi, A. 1998 Experimental investigations of shear-induced particle migration in concentrated suspensions undergoing shear. PhD thesis, University of New York.Google Scholar
Zarraga, I. E. & Leighton, D. T. 2001 Normal stress and diffusion in a dilute suspension of hard spheres undergoing simple shear. Phys. Fluids 13, 565–577.CrossRefGoogle Scholar
Zarraga, I. E., Hill, D. A. & Leighton, D. T. 2000 The characterization of the total stress of concentrated suspensions of noncolloidal spheres in Newtonian fluids. J. Rheol. 44, 185–220.CrossRefGoogle Scholar
Zhang, K. & Acrivos, A. 1994 Viscous resuspension in fully developed laminar pipe flows. Intl J. Multiphase Flow 20, 579–591.CrossRefGoogle Scholar