Hostname: page-component-586b7cd67f-r5fsc Total loading time: 0 Render date: 2024-11-28T04:11:03.038Z Has data issue: false hasContentIssue false
  • English
  • Français

A Wide Band Gap Boron-doped Microcrystalline Silicon Film Obtained with VHF Glow Discharge Method

Published online by Cambridge University Press:  01 February 2011

Zhu feng ,
Zhao ying ,
Wei changcun ,
Zhang xiaodan ,
Gao yantao ,
Sun jian  and
Geng xinhua
Zhu feng
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Zhao ying
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Wei changcun
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Zhang xiaodan
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Gao yantao
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Sun jian
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Geng xinhua
Affiliation:
Institute of photo-electronics thin film devices and technique of Nankai University Key Laboratory of photo-electronics thin film devices and technique of Tianjin Key Laboratory of Opto-electronic Information Science and Technology Tianjin, China
Get access

Abstract

A wide bandgap microcrystalline silicon film for the window layer of microcrystalline silicon thin film solar cells was obtained with very high frequency (VHF) glow discharge technology. The material was deposited on corning 7059 substrate at about 170 When H2/SiH4 was more than 100, Raman spectra showed that this material was highly crystallized, and no peak correlation with amorphous silicon was observed. This material showed strong n type before any intentional doping. We considered that the unintentional doping of oxygen and unpurified gases. The doping performance of this material was investigated by introducing B2H6 into the reacting gas. As increasing the rate of B2H6/SiH4 from zero to 0.5%, the conductivity changed from 10-1S.cm-1 (n type) to 10-8 S.cm-1 dramatically and than backed to 10-1 S.cm-1 (p type), which indicated that this material had excellent doping ability. Raman spectra also showed that the microstructure of these materials did not change obviously in this doping range. We gained the p-uc-Si:H film with thickness less than 30nm, and the conductivity was more than 10-2 S.cm-1, and crystalline volume fraction no less than 40%, the Egopt could be wider than 2.10eV. Using this p window layer in microcrystalline silicon solar cells with no ZnO rear reflection, the conversion efficiency was 8.30% (Voc=0.531V, Jsc=24.66mA/cm2, FF=63.41% ).

Keywords

VHF-GD microcrystalline siliconsolar cell
Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 872: Symposium J – Micro- and Nanosystems—Materials and Devices , 2005 , J15.5
Copyright
Copyright © Materials Research Society 2005

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

[1] Dasgupta, A., Lambertz, A., Vetterl, O., Finger, F., et.al. “P-LAYERS OF MICROCRYSTALLINE SILICON THIN FILM SOLAR CELLS”, 16th EPVSEC, Glasgow, 1_5 May 2000 Google Scholar
[2] Finger, F., Carius, R., Hapke, P., et.al. “Growth and structure of microcrystalline silicon prepared with glow discharge”, Mat. Res. Soc. Symp. Proc. 452 (1997) 725 Google Scholar
[3] Barua, A.K., Sarker, Arindam Ray, Swati “Use of Different Types of Window Layers for the Top and Bottom Cell of a Double Junction a-Si Solar Cell” Technical Digest of the international PVSEC-12, Jeju, Korea 2001 Google Scholar
[4] Wronski, C.R., Collins, R.W., Jiao, L., et. al. “Stable a-Si:H Based Multij- unction Solar Cells with Guidance from Real Time Optics–Annual Report, Phase I 17 July 1998-16 October 1999” August 2000 P67 Google Scholar
[5] Lihui, Guo, Rongming, Lin, “Studies on the formation of microcrystalline silicon with PEC VD under low and high working pressure”, Thin Solid Films 376 (2000) P249–254 Google Scholar
[6] hui-Dong, Yang, Chun-Ya, Wu, Hong-Bo, Li, et.al. “Diagnosis of VHF plasmas with optical emission spectroscopy”, Acta Physica Sinica, Vol.52, No.9, (2003) 2324–2330 Google Scholar
[7] Jana, Madhusudan, Das, Debajyoti, and Barua, A. K., “Role of hydrogen in controlling the growth of mc-Si:H films from argon diluted SiH4 plasma”, JOURNAL OF APPLIED PHYSICS, VoL.91, No.8, (2002) 5442–5448 Google Scholar